Tag Archives: crawl spaces

Crawlspace Skirting, Adding Spray Foam, and Rafters

Today the Pole barn Guru discusses crawlspace skirting, adding spray foam, and building with rafters instead of trusses.

DEAR POLE BARN GURU: I am planning on building a post frame home with a standard wood framed floor structure. It will have a crawlspace below but will not have concrete stem walls. The building site slopes down, some of the crawlspace may be excavated below grade, some areas will be above grade. Looking for ideas for skirting the crawlspace to provide the most appealing look at exterior side and keep out water and pests. TRENT in WALLA WALLA

DEAR TRENT: In areas where your building’s crawl space would involve excavation below grade, it might behoove you to place a permanent wood foundation between columns (https://www.awc.org/codes-standards/publications/pwf-2015).  In other areas most of our clients have run steel siding down to four inches above grade, just like typical post frame construction.

DEAR POLE BARN GURU: Looking to spray foam the Hansen pole barn we built.

I have some questions.  We ordered the kit with roof insulation and it was installed when built. I’m thinking of leaving the ceiling open so the trusses are exposed. Can the foam be sprayed over the insulation? If the insulation is removed can the foam be sprayed directly to the roof? If so do I just close off the ridge vent? On the side walls do I just close off the top that opens to the eaves? MARK in MT. AIRY

DEAR MARK: Make sure to use only closed cell spray foam. I have heard arguments both for and against using spray foam against either a weather resistant barrier (such as Tyvek) in walls or a reflective radiant barrier. For this one I would defer to an answer from whomever will be doing your foam application, since they will have to warranty their installation. Certainly you can spray foam directly to inside of steel panels – I did this in a recent addition to my own post frame building home. You will need to close off both vented ridge as well as soffit.

DEAR POLE BARN GURU: Is it possible to build a pole building roof structure with rafters rather than trusses? FRED in GREENBANK

DEAR FRED: As long as building can have either interior columns, or single sloped (within reasonable span limits) it can certainly be raftered, rather than trussed. Please see this prior article in regards to pole and raftered buildings: https://www.hansenpolebuildings.com/2012/08/stall-barn/